濾波器

■産品概述product overvlew

PWM逆變器直接驅動電機時合産生較高dv/dt的(de)共橫電壓，并由此産生軸承電流 和共模溫電流以及嚴重的(de)電磁幹挑(EMD。特别是當逆變器↔通過長蛾電績與電機連接時，由于電纜中分布參數的(de)影響，會在®電機幽産生電壓反射現象，從而在電機贈會産生2倍以上的×(de)過電壓，導緻線圖絕繩失敗。度為電氣的(de)dv/dt滋波器降低電機電境傳輔☆線效應電壓的(de)增大而衰減率，減少在電機端子上所發生的(de)峰值電β壓。

When a PWM inwerterdirecty drives a motor,it generates a highdvidt common modeε voltape,reaulting in bearing current,common modeleak÷age curent,and severe elecromagnetec interterence (EM)>.Especially when the inverter is connecled to the motor thro§ugha longcable,dueto the influence ot distrbuted parameters in the cable,voltage renectioαn phenomenon wil ccur at the motor end,resulting inmore than twice the overvoltage at₽ the motor end,leading to col insulation tilure.The dvidt titer tor electr ical purposes reduces theattenuation ratecaused by the increase in the transmisδsion line feetvottage of motorcables,andreduces the‍ peak voltage that occurs atthe motor terminals.

■産品應用product Applicatior

dw/dt濾波器是設計用于保護電機的(de)濾波器，由于變頻器與電機之間運行(πxíng)電纜過長會引起對電機産生毀滅性影(yǐng‌)響峰值電壓。電纜的(de)長度取決于用在變頻器中的(de)電力半導體的(de↓)開關次數和電機的(de)大小，如果點看短到2.5米則會導緻電機✔(jī)承受的(de)峰值電壓超過電機絕緣系統的(de)額定值。然而，如果電組太長則 問題更大，在這種情況下就潛要用dv/dt濾波器來保護電機不(↓bù)受峰值電壓的(de)殿滅性影響

Dv/dtfiter isa filter dasigned to protectmotors.Due to the longrunning Ωcable betweenthefrequency converter andthe motor,itcan causede€structive effects on themotors peakvoltage.The lengthof the cabledependson thenu↓mber ofswitchesof the powersemlconductorusedin thefrequency converterand the size of themotor.I‍fthe distancelsasshort as2.5meters,it will cause thepeakvoltage borne bythemotor to exceed t"herated value ofthemotorinsulation system.However,if the cableis too long.th₽eproblem becomes even greater,inwhichcaseadv/dt filter isneede£dtoprotect the motor from thedestructiveeffects of peakvoltage.

■技術規格Tachnical specifications

+最大工作電壓：400VAC-1140VAC
·額定電魂：5-500A+輛率：50-60Hz
·防護等級：IP00-IP20絕緣等級：classF₂H
·使用環境：-10-+45℃,額定值不會降任。最高可達+55℃,在45℃以上，每升高1℃,額定電 (diàn)流降任2%
·電境長度：<1000m
+過載電流：1.5×額定電流，持續605
·噪音：≤65dB+溫升：≤70K
+抗電強度；鐵芯統組3000VAC/50Hz/5mA/10s無飛孤擊穿(工廠測試)絕緣電阻：1000VDC絕×綠阻值100M0
·海拔高度不超過2000米
·運行環境溫度-25℃-+45℃,相對濕度不垣過90%周國無有害氣體，無易煙易焊∞物品
·周國環境應有良好的(de)通風條件，如★(rú)裝在櫃內，應加裝通風設備

■執行标準Execution standards

IEC289:1987Reactor
G810229-88Reactor(eqviEC289:1987)J89644-1999 Reactorsusedforsemiconduc₽tor electricaldriving